elect fuel pump in tank
Moderators: rickf, raymond, Mr. Recovery
-
- 1st Lieutenant
- Posts: 911
- Joined: December 19th, 2011, 12:31 pm
- Location: eustis fl
elect fuel pump in tank
Hey All,
I was driving the 151 today and the fuel pump quit , What is the proper way to test it?
I put a meter on the power source and have power to unit.
Do I have to remove pump for any further investigation.
2nd ,
Where can I purchase a new one if need be?
REGARDS
lINDSAY
I was driving the 151 today and the fuel pump quit , What is the proper way to test it?
I put a meter on the power source and have power to unit.
Do I have to remove pump for any further investigation.
2nd ,
Where can I purchase a new one if need be?
REGARDS
lINDSAY
1967 M-35-a2-D SOLD
1973 M151A2
M151 A1-SOLD
196? franken MUTT
M1oo trailer-sold
1963 M151-sold
1968 M416 trailer
1988 998 Humvee-4 man
1994 998 Humvee-up armored
1973 M151A2
M151 A1-SOLD
196? franken MUTT
M1oo trailer-sold
1963 M151-sold
1968 M416 trailer
1988 998 Humvee-4 man
1994 998 Humvee-up armored
Re: elect fuel pump in tank
First and foremost, do you have oil pressure? No pressure, no pump. They do not usually just quit like that but the wires have been known to break inside the tank. Th4ee pump will have to be removed to check this but be sure you have power to the pump and a good ground from the tank to the body. Scratch a little spot to bare metal and run a wire from there to the negative terminal on the batteries. Remember, it will only run when the starter is cranking or if there is oil pressure. If you have power at the pump terminal you can assume you have oil pressure and the switch is good and then is the time to check the ground.
Finding a new one is going to be a matter of calling around, e-bay' shows, the usual searching. There are not a lot of them around so they are hard to find and expensive when you do find one so go over the one you have well and see what is wrong with it.
Finding a new one is going to be a matter of calling around, e-bay' shows, the usual searching. There are not a lot of them around so they are hard to find and expensive when you do find one so go over the one you have well and see what is wrong with it.
1964 M151A1
1984 M1008
1967 M416
04/1952 M100
12/1952 M100- Departed
AN/TSQ-114A Trailblazer- Gone
1984 M1008
1967 M416
04/1952 M100
12/1952 M100- Departed
AN/TSQ-114A Trailblazer- Gone
-
- 1st Lieutenant
- Posts: 911
- Joined: December 19th, 2011, 12:31 pm
- Location: eustis fl
Re: elect fuel pump in tank
PROBLEM SOLVED!
I removed the pump to inspect it.
Taped it with a small hammer and it worked!!!Must have been something lodged in the ball valve!.
Thanks for responding so quickly!
I removed the pump to inspect it.
Taped it with a small hammer and it worked!!!Must have been something lodged in the ball valve!.
Thanks for responding so quickly!
1967 M-35-a2-D SOLD
1973 M151A2
M151 A1-SOLD
196? franken MUTT
M1oo trailer-sold
1963 M151-sold
1968 M416 trailer
1988 998 Humvee-4 man
1994 998 Humvee-up armored
1973 M151A2
M151 A1-SOLD
196? franken MUTT
M1oo trailer-sold
1963 M151-sold
1968 M416 trailer
1988 998 Humvee-4 man
1994 998 Humvee-up armored
Re: elect fuel pump in tank
Are you using the filter on it? I can't picture anything stopping it like that being able to get through that filter. You might want to check the wire from the pump up to the connector. Do NOT do it anywhere near the tank! If it sparks while inside the tank with the cap on then nothing will happen because there is no oxygen but if it does it with the cap off or if you have it partially out, WHOOSH!
1964 M151A1
1984 M1008
1967 M416
04/1952 M100
12/1952 M100- Departed
AN/TSQ-114A Trailblazer- Gone
1984 M1008
1967 M416
04/1952 M100
12/1952 M100- Departed
AN/TSQ-114A Trailblazer- Gone
-
- Brigadier General
- Posts: 2506
- Joined: October 1st, 2010, 12:19 am
- Location: El Dorado, Arkansas
Re: elect fuel pump in tank
I remember when I rebuilt my first jeep, had to take the pump out because it wasn't working, got it cleaned up and working, put it back in, ran a jumper wire over to it to make sue it was still working in the tank, soon as I touched it to the battery it shorted out where the wire comes through the tank and held on by nut, come to find out I left out an insulator, can't believe it didn't blow.
Re: elect fuel pump in tank
There is not enough oxygen in a tank and that is why an electric pump is safe there. In the case of a military tank with that huge opening I would think if it sparked with the cap off it could get exciting. In 26 years as a firefighter I NEVER saw a gas tank "blow up". The movies would love to have you think they do but when they do anything it is usually a big WHOOSH followed by a lot of flaming gasoline. Now in Vietnam and I am sure back all the way to WWII the enemy would wrap rubber bands around a hand grenade and drop it in the tank after taking out the screen and run away. It did not take very long for the gas to dissolve the rubber band and then those did explode!
1964 M151A1
1984 M1008
1967 M416
04/1952 M100
12/1952 M100- Departed
AN/TSQ-114A Trailblazer- Gone
1984 M1008
1967 M416
04/1952 M100
12/1952 M100- Departed
AN/TSQ-114A Trailblazer- Gone
-
- 1st Lieutenant
- Posts: 911
- Joined: December 19th, 2011, 12:31 pm
- Location: eustis fl
Re: elect fuel pump in tank
I bench tested it ! filter was on but lower felt gasket was shredded!
I also re shrink wrapped area where pump wire goes through top of tank.
I also re shrink wrapped area where pump wire goes through top of tank.
1967 M-35-a2-D SOLD
1973 M151A2
M151 A1-SOLD
196? franken MUTT
M1oo trailer-sold
1963 M151-sold
1968 M416 trailer
1988 998 Humvee-4 man
1994 998 Humvee-up armored
1973 M151A2
M151 A1-SOLD
196? franken MUTT
M1oo trailer-sold
1963 M151-sold
1968 M416 trailer
1988 998 Humvee-4 man
1994 998 Humvee-up armored
Re: elect fuel pump in tank
I piece of gasket material could clog it. It may have been that but keep in mind that the piece will be moving up the line now.
1964 M151A1
1984 M1008
1967 M416
04/1952 M100
12/1952 M100- Departed
AN/TSQ-114A Trailblazer- Gone
1984 M1008
1967 M416
04/1952 M100
12/1952 M100- Departed
AN/TSQ-114A Trailblazer- Gone
-
- 1st Lieutenant
- Posts: 911
- Joined: December 19th, 2011, 12:31 pm
- Location: eustis fl
Re: elect fuel pump in tank
Step ahead ! purged line , blew it out with compressed air
1967 M-35-a2-D SOLD
1973 M151A2
M151 A1-SOLD
196? franken MUTT
M1oo trailer-sold
1963 M151-sold
1968 M416 trailer
1988 998 Humvee-4 man
1994 998 Humvee-up armored
1973 M151A2
M151 A1-SOLD
196? franken MUTT
M1oo trailer-sold
1963 M151-sold
1968 M416 trailer
1988 998 Humvee-4 man
1994 998 Humvee-up armored
Re: elect fuel pump in tank
1964 M151A1
1984 M1008
1967 M416
04/1952 M100
12/1952 M100- Departed
AN/TSQ-114A Trailblazer- Gone
1984 M1008
1967 M416
04/1952 M100
12/1952 M100- Departed
AN/TSQ-114A Trailblazer- Gone